Product ID:LORD 305-2 EPOXY ADHESIVE, PART 2 OF 2
MSDS Date:01/29/1998
FSC:NIIN:Submitter:N EN
Status Code:A
Kit Part:Y
MSDS Number: CLFVR

Emergency Phone: 814-763-2345

Info Phone: 814-868-3611

Cage: 30676

Telephone: 814-868-3611

Cage: 30676

AMINE COMPOUND

CAS: 112-24-3

RTECS: YE6650000

OSHA PEL N.E.

ACGIH TLV: N.E.

POLYAMIDE RESIN

CAS: 68410-23-1

OSHA PEL N.E.

ACGIH TLV: N.E.

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT IS LISTED AS A ROUTE OF
ENTRY . EYE: MAY CAUSE EYE IRRITATION. SKIN: MAY CAUSE SKIN
IRRITATION. MAY CAUSE SKIN SENSITIZATION. MAY CAUSE DERMATITIS.
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION. INGESTION:
HARMFUL IF SWALLOWED. INGESTION IS NOT AN EXPECTED ROUTE OF ENTRY
IN INDUSTRIAL OR COMMERICAL USES. CHRONIC: CHRONIC SKIN CONTACT
MAY CAUSE DERMATITIS.
Effects of Overexposure:REFER TO HEALTH HAZARDS ACUTE AND CHRONIC.

First Aid:EYE: FLUSH EYES IMMEDIATELY WITH LARGE AMOUNT OF WATER FOR AT
LEAST 15 MINUTES HOLDING EYELIDS OPEN WHILE FLUSHING. GET PROMPT
MEDICAL ATTENTION. SKIN: FLUSH CONTAMINATED SKIN WITH LARGE AMOUNTS
OF WA TER WHILE REMOVING CONTAMINATED CLOTHING. WASH AFFECTED SKIN
AREAS WITH SOAP AND WATER. GET MEDICAL ATTENTION OF SYMPTOMS OCCUR.
INHALATION: MOVE PERSON TO FRESH AIR. RESTORE AND SUPPORT CONTINUED
BRE ATHING. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE
MEDICAL ATTENTION. INGESTION: IF SWALLOWED, DO NOT INDUCE VOMITING.
GIVE VICTIM ONE OR TWO GLASSES OF WATER OR MILK. (OTHER
INFORMATION)

Flash Point Method:SCC
Flash Point:>93.3C, 200.F
Autoignition Temp:Autoignition Temp Text:N.D.
Lower Limits:N.A.
Upper Limits:N.A.
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR FULL FIREFIGHTING PROTECTIVE CLOTHING,
INCLUDING SELF CONTAINED BREATHING APPARATUS (SCBA). IF WATER IS
USED, FOG NOZZLES ARE PREFERABLE. DURING A FIRE, IRRITATING AND/OR
TOXIC GASES AND PARTICUL ATE MAY BE GENERATED BY THERMAL
DECOMPOSITION OR COMBUSTION.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. CLOSED
CONTAINERS MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT. USE WATER
SPRAY TO KEEP FIRE EXPOSED CONTAINERS COOL.

Spill Release Procedures:KEEP NON-ESSENTIAL PERSONNEL A SAFE DISTANCE
AWAY FROM THE SPILL AREA. AVOID BREATHING VAPORS. USE SELF
CONTAINED BREATHING EQUIPMENT. NOTIFY APPROPRIATE AUTHORITIES IF
NECESSARY. AVOID CONTACT. BEFOR E ATTEMPTING CLEANUP, REFER TO
HAZARD CAUTION INFORMATION IN OTHER SECTIONS OF THE MSDS FORM.
SCOOP SPILLED MATERIAL INTO AN APPROPRIATE CONTAINER FOR PROPER
(NEUTRALIZING AGENT)
Neutralizing Agent:N/P. SPILL RELEASE PRODECURES (CONT'D): DISPOSAL.
USE INERT ABSORBENT MATERIAL TO AID IN CONTAINING THE SPILL.

Handling and Storage Precautions:STORAGE: STORE IN A WELL VENTILATED
AREA. KEEP CONTAINER CLOSED WHEN NOT IN USE. HANDLING: KEEP
CLOSURE TIGHT AND CONTAINER UPRIGHT TO PREVENT LEAKAGE. AVOID SKIN
AND EYE CONTACT. WASH THOROUGHLY AFT ER HANDLING.
Other Precautions:AVOID BREATHING OF VAPOR OR SPRAY MISTS. DO NOT
HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
EMPTY CONTAINERS SHOULD NOT BE RE-USED. USE WITH ADEQUATE
VENTILATION.

Respiratory Protection:USE A NIOSH APPROVED AIR-PURIFYING ORGAINC VAPOR
RESPIRATOR IF OCCUPATIONAL LIMITS ARE EXCEEDED. FOR EMERGENCY
SITUATIONS, CONFINED SPACE USE, OR OTHER CONDITIONS WHERE EXPOSURE
LIMITS MAY BE GREATLY EXCEEDED, USE NIOSH APPROVED AIR-SUPPLIED
RESPIRATOR. OBSERVE OSHA REGULATIONS (29CFR 1910.134) FOR
RESPIRATOR USE.
Ventilation:SUFFICIENT VENTILATION IN PATTERN AND VOLUME SHOULD BE
PROVIDED IN ORDER TO MAINTAIN AIR CONTAMINANT LEVELS BELOW
RECOMMENDED EXPOSURE LEVELS
Protective Gloves:USE NEOPRENE, NITRILE, OR RUBBER GLOVES TO PREVENT
SKIN CONTACT.
Eye Protection:ANSI APPROVED CHEMICAL WORKER GOGGLES AND FULL
FACESHIELD . (SUPP SAFETY)
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
TOILET FACILITY. FOOD OR BEVERAGES SHOULD NOT BE CONSUMED ANYWHERE
THIS PRODUCT IS HANDLED OR STORED. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EYE PROTECTION (CONT'D): USE SAFETY EYEWEAR INCLUDING SAFETY GLASSES
WITH SIDE SHIELDS AND CHEMICAL GOGGLES WHERE SPLASHING MAY OCCUR
(MFR).

Boiling Pt:=275.C, 527.F
Melt/Freeze Pt:M.P/F.P Text:N.D.
Vapor Pres:N.D.
Vapor Density:> AIR
Spec Gravity:0.96
VOC Pounds/Gallon:9
pH:N.A.
VOC Grams/Liter:7.07
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE LIQUID. MILD ODOR.
Percent Volatiles by Volume:1.0%

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES, AND STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ORGANIC OR INORGANIC NITROGEN COMPOUNDS INCLUDING TRACES OF
HYDROGEN CYANIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS

Waste Disposal Methods:DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH
FEDERAL (40CFR PART 261), STATE AND LOCAL ENVIRONMENTAL CONTROL
REGULATIONS. IF WASTE IS DETERMINED TO BE HAZARDOUS, USE LICENSED
WASTE TRANSPORTER AND DISPO SAL FACILITY.

Toxicological Information:NO TOXICOLOGICAL INFORMATION IS AVAILABLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO INFORMATION.

Transport Information:DOT PROPER SHIPPING NAME: NOT REGULATED. DOT
HAZARD CLASS: NONE. DOT UN NUMBER: NONE. PACKING GROUP: NONE.
EMERGENCY RESPONSE GUIDE NUMBER: NONE.

SARA Title III Information:N/P.
Federal Regulatory Information:INTERNATIONAL REGULATIONS: AS FOLLOWS -
CANADIAN WHMIS: THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH
CONTROLLED PRODUCT REGULATIONS EXCEPT FOR USE OF THE 16 HEADINGS.
CANADIAN WHMIS CLASS: D2A, D2B.